Evolution Of The Media Base Flood & Drain Gutter Growbed.

My ongoing quest for cheaper and easier Aquaponics set are finally coming to an end. The traditional Flood & Drain Media Base Growbed has to go. It has been more that eight years since I started Aquaponics, initially using pebbles or stones chip then to hydroton.


The traditional media base works, it does has its pros and cons as any other type of system in Aquaponics but the one that really hamper the progress of Aquaponics in this part of the world is the cost of setting up a system. Traditional growbed are relatively expensive to setup due to the volume of LECA needed. To do large scale is almost impossible due to this.


It is not so straight forward that we can design a system and walla.. it works and at the same time reduce the cost of setting up. It takes time to test and test.. and systems evolves from these trials. I specialize in media base flood and drain using siphon and I try my best to make a system using this technique cheaper and easier to construct.


I started experiment with mini growbed system few years back when I made the single barrel set to see how well a smaller siphon control the water flow in a growbed. As with siphon, the smaller it is the more difficult to get right due to very small tolerances it has to work upon.


The barrel set above uses my midi siphon, a medium size standpipe of 20 mm, it does work but not good enough to make it a cheaper setup. It still requires lots of LECA and only the size is smaller.


I had to make something that resemble a NFT set up but has a flood and drain element in it, that is when I started experimenting with the gutter growbed few years back.


Above in 2010 was my first attempt of a gutter system, the siphon use at the time is a downward loop siphon, and it doesn't work that well. As in the photo pebbles was use and most of the time it function as a media filled DWC which has limited plant type to be grown.

In order to get a good flood and drain, the siphon must work ! The problem with siphon is the smaller it is the more difficult to get it right. My 20 mm siphon is too big for gutter setup I had to design something smaller.


It was my daughter that asked me to make something for her "Show And Tell" she asked me to make a micro Aquaponics set that demonstrate the concept of Aquaponics. To make a micro set requires a micro siphon. That when I make the smallest siphon that I currently use, takes about 2 weeks for me to figure out the design proportion and further few weeks to test the proof of concept.


15 mm siphon is actually not new to me, it was the size of the first siphon that I made for my initial Aquaponics set, at the time I was very new to Aquaponics and the siphon is just a straight standpipe with enclosure to create the siphoning. Obviously it is not a reliable siphon at the time. But instead of pursuing the 15mm siphon I took the 25mm route to make a big siphon and improve upon the design until it is what it is today.


I tried the 15mm siphon on ornamental set for almost 2 years, being first make it debut in early 2014 and many test done using the 15 mm siphon that works beautifully. After extensive testing, only then I am satisfied that now I can use the smallest siphon to run an Aquaponics set that is easy and cheap to make.


This is when I started to make the #guttergrowbed system and to make it easier I didn't put the LECA directly into the growbed but uses pots to make it easier to handle. I was worry that the potted setup do not has enough surface area for effective biological nutrification processes, but it does do well it the initial test.


It is obvious the #guttergrowbed setup is not for large plants, but for commercial intent it is viable to have crop of smaller plants and leafy vegetable at a lower cost of setup.


So finally, the traditional growbed has to go and make room for #guttergrowbed at my back lane set.


These 4 gutters is 4 meter in length each replacing my 4 traditional growbed, trials shows that it uses only 1/5 the LECA for the same area and 1/3 the electricity to run it. This is possible due plants are in pots and siphon is smaller.

So this next few weeks I'll be busy with this retrofit and I hope it does work on a larger scale setup. The design and how to will be made freely available here as my contribution to the Aquaponics community.

The final part would be going off grid, which is easily achieve due to the low power requirement of this set up. For the 4 #guttergrowbeds it only consumes 30 watt of electricity total.

Check out the Cascading Flood & Drain Gutterbed Set

35 comments:

  1. Dear En Affnan,
    I would like to know what is the width and the height of the gutter you use.?
    I just set up a set like the ornamental set you showed using 20mm siphon ..still testing . Now contemplating to set up the gutter system . Need to know the dimension of the gutter..
    Thanks.
    Salam Fr Ariffien

    ReplyDelete
    Replies
    1. This is the standard rain gutter about 4.5" inches on the base and 6.5" inches on the top end. You can easily get it from hardware store if need to test out. But most shop sell the 6 mtr or 20ft gutter. I need 13ft or 14ft growbed so the 4 meter gutter is just nice. I do not want to cut the 6 meter gutter to length because the cut usually will not be straight and problematic to get a good seal.

      Note : Not many place sell 4 meter length gutter most do the 6 meter.

      Delete
  2. Hi En Affan. Is it possible to visit ur place? My uncle is v interested in aquaponies n extremely won-over when I shared ur blog. Tx & Congrats tak terhingga!

    ReplyDelete
    Replies
    1. Sure no problem, I am always try my best to help others. Do send me email of your intent. My email is below my picture on the top right.

      Delete
  3. Boleh saya melawat tempat En. Affnan berkebun aquaponies? Nak berlajar

    ReplyDelete
    Replies
    1. Boleh tiada masaalah, email saya affnan.aquaponics@gmail.com

      Delete
  4. Hi Afnan,

    Where do I buy the Dickson frame or Franken frame from in Malaysia. Selangor?

    ReplyDelete
  5. Hi En Afnan,
    Do you provide classes? I bought aquophonic, from aquarium @ Kota damansara and it's crack and leaking after complaint exchanged still same and get scold by them. So I hope you have proper teaching, so I m able to have a proper system set up and how much it's cost. Thanks

    ReplyDelete
  6. Assalamualaikum,
    Tuan saya sangat berminat utk belajar Aquaponik mudah.Saya berhasrat hendak jemput tuan ketempat saya di IPG Teknik Bandar Enstek Nilai Negeri Sembilan untuk berkongsi Ilmu. Email saya rosmawatihjmamat@yahoo.com atau no telefon ofis saya 06- 7979601 ext 9668. tqq

    ReplyDelete
  7. Assalamualaikum,
    Tuan saya sangat berminat utk belajar Aquaponik mudah.Saya berhasrat hendak jemput tuan ketempat saya di IPG Teknik Bandar Enstek Nilai Negeri Sembilan untuk berkongsi Ilmu. Email saya rosmawatihjmamat@yahoo.com atau no telefon ofis saya 06- 7979601 ext 9668. tqq

    ReplyDelete
  8. Purely home this currently thing My husband furthermore i advised parts mostly volumes select parades. Persons eligible beside this hit path additionally you resolution explore structures who imagine about your would love.baby bow ties

    ReplyDelete
  9. Yes that is correct, sewage is released directly into the lake. Sometimes, after such an event, you can even see turds floating on the Lake. garbage disposal reviews

    ReplyDelete
  10. Thanks for sharing this interesting blog with us.My pleasure to being here on your blog..I wanna come beck here for new post from your site.Tanklessly

    ReplyDelete
  11. Thanks a lot for the article.Really looking forward to read more. Will read on... Gutter repair Raleigh NC

    ReplyDelete
  12. In many occasions, you have to know where your cesspool is located. If you own the property and you know where the cesspool is, there should be no problem Long Island Cesspool Replacement .

    ReplyDelete
  13. I definitely enjoying every little bit of it. It is a great website and nice share. I want to thank you. Good job! You guys do a great blog, and have some great contents. Keep up the good work. I really appreciate this wonderful post that you have provided for us. I assure this would be beneficial for most of the people. Gutter Company Raleigh NC

    ReplyDelete
  14. I appreciate several from the Information which has been composed, and especially the remarks posted I will visit once more.  Gutter Contractors

    ReplyDelete
  15. Great post, and great website. Thanks for the information! Des Moines Iowa cash buy inherited probate houses

    ReplyDelete
  16.  A portable fish finder is a good choice if you don't fish from the same ship all the time. Seamless gutter company

    ReplyDelete
  17. You make so many great points here that I read your article a couple of times. Your views are in accordance with my own for the most part. This is great content for your readers. smm panels list

    ReplyDelete
  18. Interesting post. I Have Been wondering about this issue. so thanks for posting. Pretty cool post.It 's really very nice and Useful post.Thanks General Contractor Maryland

    ReplyDelete
  19. I think this is an informative post and it is very beneficial and knowledgeable. Therefore, I would like to thank you for the endeavors that you have made in writing this article. All the content is absolutely well-researched. Thanks... Gutter installers in Jupiter Fl

    ReplyDelete
  20. In any case, the measurement that is most pertinent to this article is: german-transcription-services

    ReplyDelete
  21. I have to search sites with relevant information on given topic and provide them to teacher our opinion and the article. Best Trail Running Shoes for Men

    ReplyDelete
  22. Great Information sharing .. I am very happy to read this article .. thanks for giving us go through info.Fantastic nice. I appreciate this post. youngupstarts.com

    ReplyDelete
  23. Hey There. I discovered your blog the use of msn. This is a really well written article.
    I'll be sure to bookmark it and return to read extra of your helpful information.
    Thank you for the post. I'll definitely comeback. my blog: smm panel bangladesh

    ReplyDelete
  24. I read your articles very excellent and the i agree our all points because all is very good information provided this through in the post.
    Modular drainage system

    ReplyDelete
  25. Hi there, I discovered your blog per Google bit searching for such kinda educational advise moreover your inform beholds very remarkable for me. custom patches

    ReplyDelete
  26. Then again, channel lines and sewers can be as filthy as possible envision. Simply think about all that goes into the channel lines and sewer. Cleaning these lines may require a channel cleaning administration from experts. Best home plumber

    ReplyDelete
  27. Glad to chat your blog, I seem to be forward to more reliable articles and I think we all wish to thank so many good articles, blog to share with us. gutter replacement

    ReplyDelete
  28. Great thanks for sharing this article post. Really thank you! Keep writing.
    https://guttercleaningclacton.co.uk/

    ReplyDelete
  29. Apply groundwork and an undercoat of paint prior to repainting the entire window outline.

    https://www.westseattlewindowcleaner.com/pressure-washing-bellevue-homeowners-best-friend

    ReplyDelete
  30. The community here is so supportive and engaging.

    ReplyDelete